Business

<< Previous   of   Next >> Associated Press  (click to enlarge) The mechanical meter on a diesel fuel dispenser at Colville's Chevron service station can't show prices past $3.99 a gallon. Associated Press  (click to enlarge) Annette Wanzek turns on the pump before fueling a customer's car at the town's only gas pump in Windsor, N.D., May 7. The mechanical gas pump can not display prices above $3.999 a gallon without a costly overhaul.   ADVERTISEMENT   Related Stories • Gas pumps feel the pain, too 5/12/08   CONTACT THE HERALD Mike Benbow, Business Editor benbow@heraldnet.com   Published: Tuesday, May 13, 2008 Why old gas pumps can't keep up with price hikes Smaller gas stations say their old-style pumps, which can't charge more than $3.99 a gallon, are too expensive to modify or replace. Associated Press REARDAN -- Mom-and-pop service stations are running into a problem as gasoline marches toward $4 a gallon: Thousands of old-fashioned pumps can't register more than $3.99 on their spinning mechanical dials. The pumps, throwbacks to a bygone era on the American road, are difficult and expensive to upgrade, and replacing them is often out of the question for station owners who are still just scraping by. Many of the same pumps can only count up to $99.99 for the total sale, preventing owners of some SUVs, vans, trucks and tractor-trailers to fill their tanks all the way. As many as 8,500 of the nation's 170,000 service stations have old-style meters that need to be fixed -- about 17,000 individual pumps, said Bob Renkes, executive vice president of the Petroleum Equipment Institute of Tulsa, Okla. At Chip Colville's Chevron station in this Eastern Washington town, where men in the family have pumped gas since 1919, three stubby, gray pumps were installed when gas was less than $1 a gallon. They top out at $3.999, only 30 cents above the price of regular gas at Colville's station. "In small towns, where you don't have the volume, there's no way you can afford to pay for the replacements for these old pumps," Colville said. "It's just not economically feasible." The problem is worse in extremely rural areas, where "this might be the only pump in town that people can access," said Mike Rud, director of the North Dakota Petroleum Marketers Association. Demand for replacements has caused a monthslong backlog for companies that make or rebuild the mechanical meters -- and that's just for stations that can afford the upgrade. For many station owners -- who, because of relatively small profit margin on gas, aren't raking in money even though gas prices are marching higher -- replacing the pumps altogether with electronic ones is just not an option. "The new ones run between $10,000 and $15,000 apiece," Colville said. "It's an expense that's not worth it." Mechanical meters can be retrofitted with higher numbers when pump prices climb another dollar. The last time that happened was in late 2005, when gas went over $3 a gallon, and owners of the older pumps installed kits that went to $3.999. This time around, owners of the old pumps will need to install another kit that can handle prices up to $4.999, and possibly higher. Industry experts say those changes could cost as much as $650 per pump. It costs less to change the meter to raise the maximum price from $2.99 to $3.99 a gallon, but that option raises the risk of a breakdown, said Pete Turner, chief operating officer for APS Petroleum Equipment Inc. of Anniston, Ala. "The computer that they're upgrading was not designed to go any more than what it's going now, and if you do it, they don't last long enough," Turner said. "They run so fast that the gears are wearing out." The price of fixing the meters jumped in the past three years because old pumps are being phased out for new electronic pumps and demand for refurbished meters is down, Al Eichorn, vice president of PMP Corp., which makes the mechanical meters. The Avon, Conn., company has hired extra employees who are working overtime but still has a 14-week backlog of orders, Eichorn said. To deal with the problem, some state regulators are allowing half-pricing -- displaying the price for a half-gallon of gas, then doubling the price shown on the meter. In North Dakota, regulators recently told service stations their mechanical pumps could use half-pricing, provided they use signs to alert costumers and find a permanent solution by April 2009. South Dakota is preparing similar rules, officials say. And in Minnesota, rural service station owners whose pumps cannot display the right price are being told to cover up the incorrect numbers. "The consumer can only see the gallons turning," said Bill Walsh, a spokesman for the Minnesota Department of Commerce. "Then they just have to settle up with a calculator, basically." Colville and about a dozen other service station owners in Washington have received temporary variances from the state to allow them to half-price fuel. Stations granted variances are required to post signs telling customers that the final price they will pay is twice what the pump meter indicates. "No, that don't bother me. The price does," said Jim Puls, a third-generation rancher who pulled up to Colville's diesel pump to fill up his flatbed truck at $4.41 a gallon. "I can understand what they have to do."

1. Text messages led to 2 arrests in Sultan man's killing 2. Man shot to death in south Everett 3. Arrest made in early morning shooting death 4. Boeing 7-8-07 rollout : One year later 5. Hikers rescued off Mount Pilchuck 6. Governor's race gets costly; in Snohomish County, Rossi leads Gregoire in fundraising 7. Neighborhood fireworks ruin day 8. Auburn teen pleads guilty in gang-related slaying 9. Everett needs parking more than new children's theater, some businesses say 10. Miss Jessica: Racecar teacher 2 - Top 10 Stories Most Talked about 3 - Top 10 Stories Most Emailed

• PCC illegally chops three trees in Edmonds • Local lottery winner takes biggest ever prize • Man shot to death south of Everett • Terrace seeks to sharpen dog ordinance's teeth • Terrace council OKs controversial housing development • An era ends: the curtain falls on the Sonics • Red, White, and Blue: Parade photoalbum • World famous, and headed to Everett • The man in charge • Arlington Fly-In marks 40th anniversary this year • County home market offers low rates, lower prices, wide variety of prope ... • Good investments may be boring but profitable • People Watching - July 2008 • Melody Biringer a wide-ranging entrepreneur • Fryelands industrial park growing in Monroe • Out of the Blue Aviation expands flight training • Paul Allen’s rare Flying Heritage Collection becomes latest aviation att ...