The Antares rocket, developed by Orbital Sciences Corp., is going through final preparations for a 5 p.m. EDT blastoff planned for Wednesday. The eyes of the U.S. government will be on the launch to see whether the two-engine booster has the right stuff.
NASA has invested about $288 million in seed money to help the Dulles, Va., company develop its technology, and has an additional $1.9 billion on the table with a contract for eight flights to transport cargo to the International Space Station in the coming years.
"This test launch is an important milestone to validate the work the team has done over the past 4 1/2 years," Orbital spokesman Barron Beneski said. "From a business perspective, our involvement with NASA's new initiative of engaging the commercial sector to carry out the more routine low-orbit operations is an important part of our growth story and may lead to other market opportunities."
With last year's retirement of the space shuttle fleet, NASA is eager to give private industry the job of carrying cargo and crews, in hopes of cutting costs. Meanwhile, the space agency will focus on deep-space missions to land probes on asteroids and Mars.
One commercial company, Space Exploration Technologies Corp., has successfully resupplied the space station in two missions. The Hawthorne, Calif., firm, better known as SpaceX, most recently pulled off the feat last month.
The Antares test flight, more than a year late because of design and launchpad delays, is the first of two missions Orbital is scheduled to conduct in 2013 under its contract with NASA.
The two-stage rocket, powered by engines from Aerojet-General Corp. in Sacramento, is set to carry a dummy cargo capsule weighing roughly 8,300 pounds about 160 miles above Earth. NASA Television coverage of the launch will be available at http:/// www.nasa.gov/ntv.
If needed, back-up launch opportunities are available April 18-21.
The capsule will carry instruments to collect data and will remain in orbit for months until natural gravitational forces slowly degrade its orbit and it re-enters and burns up in the atmosphere.
If all goes well, Orbital plans to carry out a full flight demonstration midyear of the rocket and the Cygnus capsule that will take cargo to the space station.
But success is far from guaranteed.
The rocket industry is notoriously difficult to enter and littered with failed projects. Even the best rocket systems often require several attempts before they achieve success.
"Getting the engineering right is the next step," said Carissa Bryce Christensen, managing partner of Tauri Group, an analytic and engineering firm in Alexandria, Va. "If it's successful or not, there will be a lot learned. However, they're more likely to get more attention if they fail than if they succeed."
While Orbital acknowledges the hazards of launching a new rocket, the company remains confident about its rocket. The company has had successful missions with its last four new rockets: Pagasus, Taurus, Minotaur I and Minotaur IV. Each of those rockets performed as expected on their first five missions.
But in 2009 and 2011, Orbital ran into failures with its Taurus XL rocket. On both occasions, the rocket's protective fairing did not separate properly from the rocket and didn't allow the satellites it was carrying to reach orbit.
The failures shook the company and caused it to name its newest rocket "Antares" - rather than its original name, Taurus II, in order to prevent the public from thinking they were the same.
So when the Antares blasts off, it will be the first new rocket to be launched from a freshly built Mid-Atlantic Regional Spaceport at NASA's Wallops Flight Facility in eastern Virginia.
Although the center was established in 1945, the facility hasn't hosted high-profile launches like those at more notable launch pads in Cape Canaveral, Fla., and Vandenberg Air Force Base northwest of Santa Barbara, Calif.
At 6 square miles, Wallops' mission is to act as a resource for low-cost aerospace-based science and technology research. It's a site for launching sounding rockets, weather balloons and scientific aircraft, rather than spy satellites and manned missions.
But the state of Virginia poured $80 million - in addition to $40 billion from NASA - into developing Wallops so it could be a hub for commercial companies to routinely launch rockets. While Orbital is its only current customer, the government is in talks with other companies.
MORE HBJ HEADLINES
Homegrown appliance retailer Judd & Black marks 75 years Watchdog: Too few air traffic controllers where needed most A $32B tally, but Boeing's 787 costs don't bother Wall Street Czech airline to buy 16 Boeing 737 Max jets Lockheed Martin separating unit, combining it with Leidos Apple forecasts rare sales drop