Leveled-out ferries save sizable amount of fuel

OLYMPIA — Fuel use on two of Washington’s newer ferries is down since the state poured tons of ballast into the 64-car vessels to prevent them from leaning when empty.

And it’s adding up to thousands of dollars in savings for Washington State Ferries, whose leaders for months resisted political and public pressure to level out the boats.

Vessels in the Kwa-di Tabil class used an average of 71.7 gallons per hour in the last six months of 2013. That’s down from 83.7 gallons per hour in the same period in 2012, according to figures from the Washington State Ferries.

The 14 percent drop over a six-month stretch worked out to approximately $233,000 in savings, according to Deputy Chief Jean Baker.

“I think over the life of the vessel we’re talking tens of millions of dollars potentially in savings,” said Rep. Norma Smith, R-Clinton. “Is that significant? Absolutely.”

The figures for fuel use cover all three boats in the class — the Salish, the Kennewick and the Chetzemoka.

But officials attribute the bulk of the decline to the Salish and Kennewick, which each started burning less fuel immediately after getting weighted down with ballast last year to overcome a design feature that purposely caused them to list.

In April 2013, the state added 72.5 tons of granular steel shot to the Salish to erase its lean. Six months later, it did similar work on the Kennewick. Work on the Chetzemoka is slated this year.

Smith began in early 2012 pressing ferry officials to take steps to level the boats. Aside from the awkward way it looked, she questioned whether the boats vibrated more because of it, and therefore might not last as long.

For months, state ferries chief David Moseley resisted. He said there was no indication the boats vibrated more or would be less durable because of the design. Eventually he relented.

Once the work got under way Moseley said adding weight and pushing the propellers a couple of inches deeper into the water could improve fuel efficiency and operability of the vessels, which traverse the rough waters of Admiralty Inlet between Port Townsend and Coupeville.

“I thought it was possible. We’re pleased,” Moseley said. “I think the ballast work and the fact that the boats sit a little lower in the water is probably one of the contributing factors.”

Moseley declined to answer if the magnitude of the savings gives him pause about not doing the renovations earlier.

Smith was not reticent.

“Very early on in the operation of the vessels both the crew and the public expressed concerns,” she said. “Had those concerns been heeded sooner I think more savings and operational efficiencies could have been realized sooner.”

Rep. Larry Seaquist, D-Gig Harbor, who also pushed to add the ballast, said it’s worked out better than he anticipated.

The savings proves the boats should not have been built with a list in the first place. Part of the problem is ferry system staff helped design the class of boats and had too big a stake in it, he said.

He’s written legislation aimed at getting an independent party to oversee ferry construction contracts and reduce the role of ferry employees in designing boats. It passed the House and is awaiting consideration in the Senate.

“This is exactly the mistake of letting the ferry system do the in-house design that the bill is intended to prevent,” he said.

Jerry Cornfield: 360-352-8623; jcornfield@heraldnet.com

Talk to us

> Give us your news tips.

> Send us a letter to the editor.

> More Herald contact information.

More in Local News

A firefighter stands in silence before a panel bearing the names of L. John Regelbrugge and Kris Regelbrugge during the ten-year remembrance of the Oso landslide on Friday, March 22, 2024, at the Oso Landslide Memorial in Oso, Washington. (Ryan Berry / The Herald)
‘Flood of emotions’ as Oso Landslide Memorial opens on 10th anniversary

Friends, family and first responders held a moment of silence at 10:37 a.m. at the new 2-acre memorial off Highway 530.

Julie Petersen poses for a photo with images of her sister Christina Jefferds and Jefferds’ grand daughter Sanoah Violet Huestis next to a memorial for Sanoah at her home on March 20, 2024 in Arlington, Washington. Peterson wears her sister’s favorite color and one of her bangles. (Annie Barker / The Herald)
‘It just all came down’: An oral history of the Oso mudslide

Ten years later, The Daily Herald spoke with dozens of people — first responders, family, survivors — touched by the deadliest slide in U.S. history.

Victims of the Oso mudslide on March 22, 2014. (Courtesy photos)
Remembering the 43 lives lost in the Oso mudslide

The slide wiped out a neighborhood along Highway 530 in 2014. “Even though you feel like you’re alone in your grief, you’re really not.”

Director Lucia Schmit, right, and Deputy Director Dara Salmon inside the Snohomish County Department of Emergency Management on Friday, March 8, 2024, in Everett, Washington. (Ryan Berry / The Herald)
How Oso slide changed local emergency response ‘on virtually every level’

“In a decade, we have just really, really advanced,” through hard-earned lessons applied to the pandemic, floods and opioids.

Ron and Gail Thompson at their home on Monday, March 4, 2024 in Oso, Washington. (Olivia Vanni / The Herald)
In shadow of scarred Oso hillside, mudslide’s wounds still feel fresh

Locals reflected on living with grief and finding meaning in the wake of a catastrophe “nothing like you can ever imagine” in 2014.

Everett mall renderings from Brixton Capital. (Photo provided by the City of Everett)
Topgolf at the Everett Mall? Mayor’s hint still unconfirmed

After Cassie Franklin’s annual address, rumors circled about what “top” entertainment tenant could be landing at Everett Mall.

Everett
Everett man sentenced to 3 years of probation for mutilating animals

In 2022, neighbors reported Blayne Perez, 35, was shooting and torturing wildlife in north Everett.

Dorothy Crossman rides up on her bike to turn in her ballot  on Tuesday, Aug. 1, 2023 in Everett, Washington. (Olivia Vanni / The Herald)
Everett leaders plan to ask voters for property tax increase

City officials will spend weeks hammering out details of a ballot measure, as Everett faces a $12.6 million deficit.

Starbucks employee Zach Gabelein outside of the Mill Creek location where he works on Friday, Feb. 23, 2024 in Mill Creek, Washington. (Olivia Vanni / The Herald)
Mill Creek Starbucks votes 21-1 to form union

“We obviously are kind of on the high of that win,” store bargaining delegate Zach Gabelein said.

Lynnwood police respond to a collision on highway 99 at 176 street SW. (Photo provided by Lynnwood Police)
Police: Teen in stolen car flees cops, causes crash in Lynnwood

The crash blocked traffic for over an hour at 176th Street SW. The boy, 16, was arrested on felony warrants.

The view of Mountain Loop Mine out the window of a second floor classroom at Fairmount Elementary on Wednesday, Jan. 10, 2024 in Everett, Washington. (Olivia Vanni / The Herald)
County: Everett mining yard violated order to halt work next to school

At least 10 reports accused OMA Construction of violating a stop-work order next to Fairmount Elementary. A judge will hear the case.

Imagine Children's Museum's incoming CEO, Elizabeth "Elee" Wood. (Photo provided by Imagine Children's Museum)
Imagine Children’s Museum in Everett to welcome new CEO

Nancy Johnson, who has led Imagine Children’s Museum in Everett for 25 years, will retire in June.

Support local journalism

If you value local news, make a gift now to support the trusted journalism you get in The Daily Herald. Donations processed in this system are not tax deductible.