Two state lawmakers raise concerns over new ferry’s design

OLYMPIA — Washington’s newest ferry went into service Monday amid the concerns of two lawmakers that a flawed design is causing some vehicles to bottom out as they transition from ramps onto upper parking decks.

Under a blanket of blue sky, the Tokitae sailed on its maiden voyage at noon from Clinton to Mukilteo, with no fanfare.

The 144-car vessel, with a capacity 20 cars more than the Cathlamet it is replacing, cost $144 million and is the first of three Olympic-class boats being built for the state at the Vigor Industrial shipyard in Seattle. Total shipyard cost for the newest boats in the Washington State Ferries fleet is $388 million.

The Tokitae’s much-anticipated entry into service came as two lawmakers alleged they were misled about a problem for some cars with low clearances and long wheelbases. As they reach the upper parking deck, the lawmakers say, some scrape their undercarriage.

Reps. Norma Smith, R-Clinton, and Larry Seaquist, D-Gig Harbor, said senior ferry system managers told them in March at the shipyard that their worries were unwarranted.

But ferry workers contacted them last week to say part of their training on the vessel involved learning how to keep cars with low clearances from going up the ramps.

Ferries managers “told us in March they had looked at it, there was adequate clearance and there was not a problem,” Smith said. “We were simply misled. If the proper analysis had been done, this would never have happened.”

Capt. George Capacci, interim ferries chief, said Monday he’s tried to be as transparent as possible with the lawmakers since they first raised the concern earlier this year.

“I don’t think it’s a problem,” Capacci said. Deck hands responsible for loading and unloading cars are experienced at figuring out which vehicles can handle the transition without trouble and which might have trouble, he said.

On the Tokitae, the upper end of the ramps are sharper than those on other vessels, and that might increase the potential for scraping, Capacci said.

Testing was done by driving cars with difference clearances on the ramps. In one test, he rode in a Ford Taurus with three others and handled the ramp without difficulty, he said.

Capacci said he put in a change order to create a smoother ramp on the Samish, which is under construction, and the third as-yet unnamed vessel on which work has not yet begun.

“I do not think it’s a fatal flaw,” he said of the Tokitae design. “I think it’s one of those grooming issues you deal with when you bring a new vessel into service. There are things we do to vessels during the life of a vessel to make it better.”

A spokeswoman for Gov. Jay Inslee said that if it is a problem, the boat builder is responsible for getting it fixed.

“The governor is aware of Reps. Seaquist’s and Smith’s concerns about whether cars can safely board and unboard the vessel. WSF has sent results of test vehicles showing no problems boarding or unboarding the vessel,” spokeswoman Jaime Smith wrote in an email.

“Ultimately, the governor will hold the contractor accountable for delivering a safe vessel — any modifications to the design of other vessels is something Vigor would need to address,” she wrote.

The ferry agency’s response to their concerns spurred Smith and Seaquist to ask Inslee to appoint an independent panel of experts to “conduct a thorough and transparent investigation” of ferry operations and labor-management issues. They also want the governor to put new people in place — even before a new ferries director is hired.

“WSF must be held accountable,” the two wrote in a letter to Inslee on June 27. “To ensure improvements in the department, we are strongly advising a major overhaul of upper management in the ferries division in order to restore public trust.”

A spokeswoman for the governor said any leadership changes will have to wait until a new director is hired to run Washington State Ferries.

Capacci was one of two finalists for the job when he pulled out last month. Secretary of Transportation Lynn Peterson decided that rather than hire the other finalist, she would restart the search.

“Once the new director is in place, we can have a conversation about what he or she needs to have a team and structure in place that works,” wrote Smith, Inslee’s spokeswoman.

Jerry Cornfield: 360-352-8623; jcornfield@heraldnet.com.

Talk to us

> Give us your news tips.

> Send us a letter to the editor.

> More Herald contact information.

More in Local News

Trader Joe’s customers walk in and out of the store on Monday, Nov. 20, 2023 in Everett, Washington. (Olivia Vanni / The Herald)
New Trader Joe’s opens this week at Everett Mall

It’s a short move from a longtime location, essentially across the street, where parking was often an adventure.

Ian Bramel-Allen enters a guilty plea to second-degree murder during a plea and sentencing hearing on Wednesday, March 6, 2024, at Snohomish County Superior Court in Everett, Washington. (Ryan Berry / The Herald)
‘Deep remorse’: Man gets 17 years for friend’s fatal stabbing in Edmonds

Ian Bramel-Allen, 44, pleaded guilty Wednesday to second-degree murder for killing Bret Northcutt last year at a WinCo.

Firefighters respond to a small RV and a motorhome fire on Tuesday afternoon in Marysville. (Provided by Snohomish County Fire Distrct 22)
1 injured after RV fire, explosion near Marysville

The cause of the fire in the 11600 block of 81st Avenue NE had not been determined, fire officials said.

Ashton Dedmon appears in court during his sentencing hearing on Tuesday, March 5, 2024, at Snohomish County Superior Court in Everett, Washington. (Ryan Berry / The Herald)
Everett Navy sailor sentenced to 90 days for fatal hit and run

Ashton Dedmon crashed into Joshua Kollman and drove away. Dedmon, a petty officer on the USS Kidd, reported he had a panic attack.

A kindergarten student works on a computer at Emerson Elementary School on Wednesday, Feb. 28, 2024, in Everett, Washington. (Ryan Berry / The Herald)
‘¡Una erupción!’: Dual language programs expanding to 10 local schools

A new bill aims to support 10 new programs each year statewide. In Snohomish County, most follow a 90-10 model of Spanish and English.

Logo for news use featuring the Tulalip Indian Reservation in Snohomish County, Washington. 220118
Woman drives off cliff, dies on Tulalip Reservation

The woman fell 70 to 80 feet after driving off Priest Point Drive NW on Sunday afternoon.

Everett
Boy, 4, survives fall from Everett fourth-story apartment window

The child was being treated at Seattle Children’s. The city has a limited supply of window stops for low-income residents.

People head out to the water at low tide during an unseasonably warm day on Saturday, March 16, 2024, at Lighthouse Park in Mukilteo, Washington. (Ryan Berry / The Herald)
Everett shatters record high temperature by 11 degrees

On Saturday, it hit 73 degrees, breaking the previous record of 62 set in 2007.

Snohomish County Fire District #4 and Snohomish Regional Fire & Rescue respond to a motor vehicle collision for a car and pole. The driver was pronounced dead at the scene, near Triangle Bait & Tackle in Snohomish. (Snohomish County Sheriff’s Office)
Police: Troopers tried to stop driver before deadly crash in Snohomish

The man, 31, was driving at “a high rate of speed” when he crashed into a traffic light pole and died, investigators said.

Alan Dean, who is accused of the 1993 strangulation murder of 15-year-old Bothell girl Melissa Lee, appears in court during opening statements of his trial on Monday, March 18, 2024, at Snohomish County Superior Court in Everett, Washington. (Ryan Berry / The Herald)
31 years later, trial opens in Bothell teen’s brutal killing

In April 1993, Melissa Lee’s body was found below Edgewater Creek Bridge. It would take 27 years to arrest Alan Dean in her death.

Logo for news use featuring the municipality of Snohomish in Snohomish County, Washington. 220118
Man dies after crashing into pole in Snohomish

Just before 1 a.m., the driver crashed into a traffic light pole at the intersection of 2nd Street and Maple Avenue.

Bodies of two men recovered after falling into Eagle Falls near Index

Two men fell into the falls and did not resurface Saturday, authorities said. After a recovery effort, two bodies were found.

Support local journalism

If you value local news, make a gift now to support the trusted journalism you get in The Daily Herald. Donations processed in this system are not tax deductible.