The cockpit of a grounded Lion Air Boeing 737 Max 8 aircraft. (Dimas Ardian/Bloomberg)

The cockpit of a grounded Lion Air Boeing 737 Max 8 aircraft. (Dimas Ardian/Bloomberg)

Six minutes to disaster: Ethiopian Air

How pilots battled the Boeing 737 Max

By Alan Levin, Julie Johnsson and Mary Schlangenstein / Bloomberg

The alarms started sounding just seconds after Ethiopian Airlines Flight 302 took off on March 10 from Addis Ababa with 157 people on board.

As speed and altitude readings started going haywire, a device known as a stick shaker activated on the left side of the cockpit, where the captain sits. The mechanism makes a loud noise and rattles a pilot’s control column to warn of an impending aerodynamic stall.

But the Boeing Co. 737 Max wasn’t about to stall. Instead, a computer was getting erroneous readings from a sensor mounted like a weather vane on the jet’s nose. The malfunction triggered an anti-stall feature that forced the plane into a dive — the same system that was implicated in a crash less than five months before in Indonesia that killed 189 people.

To counteract it, the Ethiopian Airlines pilots responded with at least some of the steps that Boeing and the U.S. Federal Aviation Administration recommended after the first accident. But amid a chorus of confusing alarms, they also made a critical oversight as they struggled for control, according to three pilots with experience in accident investigations: They left the engines set nearly to maximum.

“The thrust was full bore the whole way,” said Roger Cox, a former accident investigator at the National Transportation Safety Board, who flew earlier models of the 737 while working as an airline pilot. “That is extremely curious.”

Ethiopian Transport Minister Dagmawit Moges said in a press conference Thursday that the pilots followed proper procedures issued after the October crash of a Lion Air jet. She recommended that Boeing review its flight-control system. Aviation authorities should verify that the issues have been adequately addressed “before the release of the aircraft to operations,” she said.

In an interview with CNN on Thursday, Ethiopian Airlines Chief Executive Officer Tewolde Gebremariam defended the pilots, saying the report proved the crew of EA 302 did more than what they were expected to do. “Today was a day for us to prove wrong all the speculators with false allegations,” he said, adding that the airline will remain partners with Boeing.

Ethiopian safety officials stopped short of saying the plane needs a redesign. That helped boost Boeing’s shares 2.9 percent to $395.86 at the close in New York, paring the decline since last month’s crash to 6.3 percent.

Still, the two disasters in five months have pushed Boeing into one of the biggest crises in its century-long history. The crash in Ethiopia resulted in the worldwide grounding of the 737 Max, the revamped version of a plane model that accounts for a third of Boeing’s operating profit. The accidents also prompted multiple investigations and reviews — including a criminal probe led by the U.S. Justice Department — of how U.S. regulators certified the flawed anti-stall system, known as MCAS.

The groundings are piling pressure on Boeing to come up with a fix that will keep pilots from having to make such complicated, split-second decisions to keep the 737 Max aloft. The company is redesigning its software and expects to complete the work within weeks. Among other changes, the update will keep the safety system from kicking in when only one of the sensors detects a stall.

“We at Boeing are sorry for the lives lost in the recent 737 Max accidents,” CEO Dennis Muilenburg said in a video. The Chicago-based planemaker blamed the accident on “a chain of events” and acknowledged the sensor malfunction.

At near-maximum thrust, the plane became more difficult to fly, multiplying the problems created by the flaw in the 737 Max’s software, according to pilots who reviewed a preliminary report issued Thursday by Ethiopia’s Aircraft Accident Investigation Bureau. High speed also made it impossible to recover in the final seconds when the plane’s nose pointed downward into their final, high-speed dive.

“They exacerbated it,” said Jeffrey Guzzetti, the former director of the FAA’s Accident Investigation Division.

The Ethiopian report clearly showed that MCAS — the Maneuvering Characteristics Augmentation System, a safety measure added to the new plane to prevent it from dangerous stalls — had activated multiple times. That was similar to the Lion Air crash.

Sensors in the aircraft that report how high its nose is pointed relative to oncoming air varied by almost 60 degrees. One of the “angle-of-attack” gauges read 15.3 degrees, likely an accurate reading for a plane taking off. The other erroneously read 74.5 degrees — which would suggest a plane pointing almost straight skyward.

Even though pilots took at least some of the steps recommended by Boeing and the FAA to counteract MCAS, they were confused and ultimately lost control, according to the report.

“As pilots have told us, erroneous activation of the MCAS function can add to what is already a high workload environment,” Muilenburg said in his statement. “It’s our responsibility to eliminate this risk. We own it and we know how to do it.”

Every plane crash typically involves multiple contributors, and the detailed Ethiopian report chronicles many factors that occurred over a matter of minutes leading to the accident.

“Everyone can talk about it from a desk, but when you see it happening it’s another thing,” said Dennis Tajer, a spokesman for the Allied Pilots Association at American Airlines. “What steps were taken, what steps were missed? Those are all things we’re going to be looking at for several weeks.”

“Boeing may have to pay about $1 billion to settle the multiple wrongful-death lawsuits filed against it on behalf of victims of the Lion Air and Ethiopian Airlines 737 Max 8 crashes,” said Holly Froum, litigation analyst.

Pilots interviewed by Bloomberg didn’t agree completely about the factors.

Some took issue with Ethiopia’s transport minister, saying the Ethiopian Airlines pilots had actually failed to properly follow the procedures. Other pilots said the flight crew’s actions were understandable given the chaotic situation.

But they all agreed that the speed was critical.

The plane took off at 94 percent of full power, according to the report. That is normal for liftoff, but pilots then typically pull back the power soon afterward. Even though the captain called for setting the speed at 238 knots, or 274 miles per hour, about a minute after takeoff, the engine thrust remained at the same level for the entire short flight, according to the report.

Before it picked up speed in its final dive, the plane was flying as fast as 365 knots, or 420 miles an hour — almost twice the usual top speed at that low altitude. In addition to the multiple warnings prompted by the MCAS failure, the pilots were also getting audible alerts indicating they had exceeded the safe flying speed, according to the report.

The Ethiopian crew followed one important step required to deal with an MCAS failure when they shut off power to the motor the system uses to automatically drive down the nose, according to the report.

However, at the high speed at which they were flying, it became much harder to adjust the plane’s pitch manually, said John Cox, president of Safety Operating Systems and a former airline pilot.

For more than two minutes during the flight with the trim system powered off, the crew had to apply strong pressure to their control column to continue flying, according to the report. Normally, pilots would adjust the wing at the tail of the plane to make the nose point upwards and reduce that pressure.

During that time, the captain asked the copilot to try making adjustments — known as trimming — manually. “The first officer replied that it is not working,” according to the report. The two wheels that pilots turn by hand to trim would have been “very hard to move or impossible” at that speed, John Cox said.

While it’s not clear from the report exactly what steps the pilots took, their struggles to keep the plane climbing apparently led them to switch power back on to the trim system. About 30 seconds before they crashed, it was activated by the pilots to slightly raise the nose.

Five seconds later, MCAS engaged again, once more pushing down the nose. At that speed, they couldn’t overcome the dive using their control column alone, according to John Cox and Guzzetti. For reasons that haven’t been explained, they didn’t try to also trim the plane using switches on their control yokes.

The plane eventually pointed down by 40 degrees and the plane reached speeds of 575 miles per hour.

“You can’t read the transcript and not put yourself in the cockpit,” Tajer, of the Allied Pilots Association, said. “Every honest pilot says, I could see me right there, doing that, even if it was not a good thing, or saying, yeah that makes sense.”

Bloomberg’s Nizar Manek, Todd Shields and Lucca de Paoli contributed to this report.

Talk to us

More in Nation-World

FILE - Britain's Queen Elizabeth II looks on during a visit to officially open the new building at Thames Hospice, Maidenhead, England July 15, 2022. Buckingham Palace says Queen Elizabeth II is under medical supervision as doctors are “concerned for Her Majesty’s health.” The announcement comes a day after the 96-year-old monarch canceled a meeting of her Privy Council and was told to rest. (Kirsty O'Connor/Pool Photo via AP, File)
Queen Elizabeth II dead at 96 after 70 years on the throne

Britain’s longest-reigning monarch and a rock of stability across much of a turbulent century died Thursday.

A woman reacts as she prepares to leave an area for relatives of the passengers aboard China Eastern's flight MU5735 at the Guangzhou Baiyun International Airport, Tuesday, March 22, 2022, in Guangzhou. No survivors have been found as rescuers on Tuesday searched the scattered wreckage of a China Eastern plane carrying 132 people that crashed a day earlier on a wooded mountainside in China's worst air disaster in more than a decade. (AP Photo/Ng Han Guan)
No survivors found in crash of Boeing 737 in China

What caused the plane to drop out of the sky shortly before it was to being its descent remained a mystery.

In this photo taken by mobile phone released by Xinhua News Agency, a piece of wreckage of the China Eastern's flight MU5735 are seen after it crashed on the mountain in Tengxian County, south China's Guangxi Zhuang Autonomous Region on Monday, March 21, 2022. A China Eastern Boeing 737-800 with 132 people on board crashed in a remote mountainous area of southern China on Monday, officials said, setting off a forest fire visible from space in the country's worst air disaster in nearly a decade. (Xinhua via AP)
Boeing 737 crashes in southern China with 132 aboard

More than 15 hours after communication was lost with the plane, there was still no word of survivors.

In this photo taken from video provided by the Ukrainian Presidential Press Office, Ukrainian President Volodymyr Zelenskyy speaks to the nation in Kyiv, Ukraine, Sunday, Feb. 27, 2022. Street fighting broke out in Ukraine's second-largest city Sunday and Russian troops put increasing pressure on strategic ports in the country's south following a wave of attacks on airfields and fuel facilities elsewhere that appeared to mark a new phase of Russia's invasion. (Ukrainian Presidential Press Office via AP)
Ukraine wants EU membership, but accession often takes years

President Volodymyr Zelenskyy’s request has enthusiastic support from several member states.

FILE - Ukrainian servicemen walk by fragments of a downed aircraft,  in in Kyiv, Ukraine, Friday, Feb. 25, 2022. The International Criminal Court's prosecutor has put combatants and their commanders on notice that he is monitoring Russia's invasion of Ukraine and has jurisdiction to prosecute war crimes and crimes against humanity. But, at the same time, Prosecutor Karim Khan acknowledges that he cannot investigate the crime of aggression. (AP Photo/Oleksandr Ratushniak, File)
ICC prosecutor to open probe into war crimes in Ukraine

U.N. human rights chief Michelle Bachelet confirmed that 102 civilians have been killed.

FILE - Refugees fleeing conflict from neighboring Ukraine arrive to Zahony, Hungary, Sunday, Feb. 27, 2022. As hundreds of thousands of Ukrainians seek refuge in neighboring countries, cradling children in one arm and clutching belongings in the other, leaders in Poland, Hungary, Bulgaria, Moldova and Romania are offering a hearty welcome. (AP Photo/Anna Szilagyi, File)
Europe welcomes Ukrainian refugees — others, less so

It is a stark difference from treatment given to migrants and refugees from the Middle East and Africa.

Afghan evacuees disembark the plane and board a bus after landing at Skopje International Airport, North Macedonia, on Wednesday, Sept. 15, 2021. North Macedonia has hosted another group of 44 Afghan evacuees on Wednesday where they will be sheltered temporarily till their transfer to final destinations. (AP Photo/Boris Grdanoski)
‘They are safe here.’ Snohomish County welcomes hundreds of Afghans

The county’s welcoming center has been a hub of services and assistance for migrants fleeing Afghanistan since October.

FILE - In this April 15, 2019, file photo, a vendor makes change for a marijuana customer at a cannabis marketplace in Los Angeles. An unwelcome trend is emerging in California, as the nation's most populous state enters its fifth year of broad legal marijuana sales. Industry experts say a growing number of license holders are secretly operating in the illegal market — working both sides of the economy to make ends meet. (AP Photo/Richard Vogel, File)
In California pot market, a hazy line between legal and not

Industry insiders say the practice of working simultaneously in the legal and illicit markets is a financial reality.

19 dead, including 9 children, in NYC apartment fire

More than five dozen people were injured and 13 people were still in critical condition in the hospital.

15 dead after Russian skydiver plane crashes

The L-410, a Czech-made twin-engine turboprop, crashed near the town of Menzelinsk.

FILE - In this March 29, 2018, file photo, the logo for Facebook appears on screens at the Nasdaq MarketSite in New York's Times Square. Facebook prematurely turned off safeguards designed to thwart misinformation and rabble rousing after Joe Biden defeated Donald Trump in the 2020 elections in a moneymaking move that a company whistleblower alleges contributed to the deadly Jan. 6, 2021, invasion of the U.S. Capitol. (AP Photo/Richard Drew, File)
Facebook, WhatsApp, Instagram in hourslong worldwide outage

Something made the social media giant’s routes inaccessable to the rest of the internet.

Oil washed up on Huntington Beach, Calif., on Sunday, Oct. 3, 2021. A major oil spill off the coast of Southern California fouled popular beaches and killed wildlife while crews scrambled Sunday to contain the crude before it spread further into protected wetlands. (AP Photo/Ringo H.W. Chiu)
Crews race to limited damage from California oil spill

At least 126,000 gallons (572,807 liters) of oil spilled into the waters off Orange County.